最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
Al-9.4Zn-1.9Mg-2.0Cu合金的熱變形流變行為與本構方程
作者:
作者單位:

有研工程技術研究院有限公司，有色金屬材料制備加工國家重點實驗室

作者簡介:

通訊作者:

中圖分類號:

基金項目:


Flow behaviors and corresponding constitutive equation of the Al-9.4Zn-1.9Mg-2.0Cu alloy
Author:
Affiliation:

State Key Laboratory of Nonferrous Metals and Processes, GRIMAT Engineering Institute Co., Ltd.

Fund Project:

the National Key and Development Program of China (No. 2016YFB0300803, 2016YFB0300903)

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    本文對Al-9.39Zn-1.92Mg-1.98Cu合金做等溫?zé)崮M壓縮實驗，變形溫度為300 ℃~460 ℃，應變速率為0.001 s-1~10 s-1，變形量為60%。結果表明：變形時,合金的流變應力力隨著變形溫度的降低或應變速率的增大而增大。由于熱變形時存在摩擦影響，對流變應力曲線進行修正.結果發現摩擦修正后的應力值低于實驗值，摩擦力對流變應力的影響程度隨著溫度的降低和應變速率的增大而增大?；诮?jīng)典的Arrhenius方程，考慮應變量對材料常數(α，n，Q和A)的影響，構建該合金在熱變形時的本構方程。評價改進的本構方程預測能力發現流變應力值與實測值吻合度較高，其相關度高達93.5%。

    Abstract:

    Hot compression tests of the Al-9.39Zn-1.92Mg-1.98Cu alloy are carried out in the temperature range from 300 ?C to 460 ?C and the strain rate range from 0.001 s-1 to 1 s-1, and the height reduction degree is 70%. The flow stress is corrected because of the effect of friction. Results show the flow stress decreases with increasing the temperature increasing or decreasing the strain rate. The friction effect is more and more obvious when the temperature is low and the strain rate is high. A revised constitutive equation considering the influence of strain is established based on the Arrhenius-type model. Compared with the experimental and predicted flow stresses, the revised constitutive equation has a higher accuracy. Their correlation coefficient and average absolute relative error is 0.95 and 2.45%, respectively.

    參考文獻
    相似文獻
    引證文獻
引用本文

石國輝,張永安,李錫武,李志輝,閆麗珍,閆宏偉,劉紅偉,熊柏青. Al-9.4Zn-1.9Mg-2.0Cu合金的熱變形流變行為與本構方程[J].稀有金屬材料與工程,2019,48(9):2753~2758.[Guohui Shi, Yongan Zhang, Xiwu Li, Zhihui Li, Lizhen Yan, Hongwei Yan, Hongwei Liu, Baiqing Xiong. Flow behaviors and corresponding constitutive equation of the Al-9.4Zn-1.9Mg-2.0Cu alloy[J]. Rare Metal Materials and Engineering,2019,48(9):2753~2758.]
DOI：10.12442/j. issn.1002-185X. E20190007

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2019-02-20
  • 最后修改日期:2019-07-01
  • 錄用日期:2019-05-09
  • 在線發布日期: 2019-10-09
  • 出版日期: