70Al7.5Ni8Cu14.5（70Zr）、Zr55Al10Ni5Cu30（55Zr）和(Zr0.75Hf0.25)65Al7.5Ni10Cu17.5（65Zr0.75Hf0.25）厘米級金屬玻璃焓和硬度弛豫的影響。結果顯示：70Zr和55Zr合金的結構弛豫表現為單峰現象，在退火溫度（Ta）接近玻璃轉變溫度（Tg）時出現弛豫峰；而65Zr0.75Hf0.25合金的結構弛豫表現為雙峰現象，分別在523和648 K（接近Tg）時出現焓弛豫峰。70Zr和55Zr合金在Tg溫度附近出現明顯的單峰弛豫行為，表明合金在Tg之前的整個溫度范圍內具有較高的抵抗退火誘導結構弛豫的能力；另一方面，65Zr0.75Hf0.25合金在523 K附近出現一個弛豫子峰，可能是由于Zr-Hf原子對的鍵合性較弱，混合焓接近于零，隨后在Tg附近出現明顯的主弛豫。65Zr0.75Hf0.25和(Zr0.5Hf0.5)65Al7.5Ni10Cu17.5（65Zr0.5Hf0.5）合金的硬度也表現出類似的雙峰現象，導致第一峰的Ta與焓弛豫峰的Ta一致。結果表明，滿足非晶形成三原則的Zr、Al、Ni和Cu組成的類二十面體中程有序結構在低Ta溫度下保持穩定；只有背離非晶形成三原則的65Zr0.75Hf0.25和65Zr0.5Hf0.5金屬玻璃焓弛豫和硬度弛豫出現了雙峰，表明形成大塊金屬玻璃非必要組元的增加將導致合金結構在低溫退火過程中的不穩定性。"/>

最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
Hf對Zr-Al-Ni-Cu金屬玻璃弛豫行為的影響
作者:
作者單位:

1.上海應用技術大學 機械工程學院，上海 200240;2.上海交大智邦科技有限公司，上海 200240

作者簡介:

通訊作者:

中圖分類號:

基金項目:

NSFC (Grant No. 51901133)


Influence of Hf on Relaxation Behavior of Zr-Al-Ni-Cu Glassy Alloys
Author:
Affiliation:

1.School of Mechanical Engineering, Shanghai Institute of Technology, Shanghai 200240, China;2.Shanghai SmartState Technology Co., Ltd, Shanghai 200240, China

Fund Project:

National Natural Science Foundation of China (51901133); The Introduction of Talents and Scientific Research Project (YJ2021-49); Shanghai University Young Teacher Training Funding Program (ZZ202212056)

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    通過測定快淬態和退火態比熱與溫度的關系，研究了Hf元素對Zr70Al7.5Ni8Cu14.5（70Zr）、Zr55Al10Ni5Cu30（55Zr）和(Zr0.75Hf0.25)65Al7.5Ni10Cu17.5（65Zr0.75Hf0.25）厘米級金屬玻璃焓和硬度弛豫的影響。結果顯示：70Zr和55Zr合金的結構弛豫表現為單峰現象，在退火溫度（Ta）接近玻璃轉變溫度（Tg）時出現弛豫峰；而65Zr0.75Hf0.25合金的結構弛豫表現為雙峰現象，分別在523和648 K（接近Tg）時出現焓弛豫峰。70Zr和55Zr合金在Tg溫度附近出現明顯的單峰弛豫行為，表明合金在Tg之前的整個溫度范圍內具有較高的抵抗退火誘導結構弛豫的能力；另一方面，65Zr0.75Hf0.25合金在523 K附近出現一個弛豫子峰，可能是由于Zr-Hf原子對的鍵合性較弱，混合焓接近于零，隨后在Tg附近出現明顯的主弛豫。65Zr0.75Hf0.25和(Zr0.5Hf0.5)65Al7.5Ni10Cu17.5（65Zr0.5Hf0.5）合金的硬度也表現出類似的雙峰現象，導致第一峰的Ta與焓弛豫峰的Ta一致。結果表明，滿足非晶形成三原則的Zr、Al、Ni和Cu組成的類二十面體中程有序結構在低Ta溫度下保持穩定；只有背離非晶形成三原則的65Zr0.75Hf0.25和65Zr0.5Hf0.5金屬玻璃焓弛豫和硬度弛豫出現了雙峰，表明形成大塊金屬玻璃非必要組元的增加將導致合金結構在低溫退火過程中的不穩定性。

    Abstract:

    The influence of Hf element on enthalpy and hardness relaxation behavior of Zr70Al7.5Ni8Cu14.5 (70Zr), Zr55Al10Ni5Cu30 (55Zr) and (Zr0.75Hf0.25)65Al7.5Ni10Cu17.5 (65Zr0.75Hf0.25) bulk glass-type alloys with large diameters of centimeter-level was examined by measuring the temperature dependence of apparent specific heats in as-spun and annealed states. Results show that the structural relaxation of 70Zr and 55Zr alloys occurs through a single-stage mode where the relaxation peak is observed at the annealing temperature (Ta) near glass transition temperature (Tg), while 65Zr0.75Hf0.25 alloy shows a double-stage reaction with enthalpy relaxation peaks appearing at 523 and 648 K near Tg. The single-stage relaxation mode for 70Zr and 55Zr alloys indicates that these alloys have high resistance to annealing-induced relaxation over the whole temperature range up to Tg, because the distinct relaxation occurs only around the temperature of Tg. 65Zr0.75Hf0.25 glassy alloy shows a relaxation sub-peak around 523 K presumably due to the weaker bonding nature of Zr-Hf atomic pair with nearly zero in heat of mixing, and the distinct main relaxation occurs near Tg. The Vickers hardness also shows the similar double-stage peak behavior as a function of Ta for 65Zr0.75Hf0.25 as well as (Zr0.5Hf0.5)65-Al7.5Ni10Cu17.5 (65Zr0.5Hf0.5) alloys, so the Ta for the first-stage hardness peak agrees with that for the enthalpy relaxation. These results imply that icosahedral-like medium range ordered structure consisting of Zr, Al, Ni and Cu elements with the three components rule for stabilization of supercooled liquid remains stable during the low Ta relaxation. The double-stage enthalpy and hardness relaxation only appear in 65Zr0.75Hf0.25 and 65Zr0.5Hf0.5 glassy alloys which deviate from the three components rule, implying that the unnecessary multiplication for the formation of bulk glassy alloys leads to an increase in structural instability during low-temperature annealing.

    參考文獻
    相似文獻
    引證文獻
引用本文

王興華,王廣濤,劉小龍,孟潤心,劉小紅.Hf對Zr-Al-Ni-Cu金屬玻璃弛豫行為的影響[J].稀有金屬材料與工程,2024,53(3):651~659.[Wang Xinghua, Wang Guangtao, Liu Xiaolong, Meng Runxin, Liu Xiaohong. Influence of Hf on Relaxation Behavior of Zr-Al-Ni-Cu Glassy Alloys[J]. Rare Metal Materials and Engineering,2024,53(3):651~659.]
DOI：10.12442/j. issn.1002-185X.20230100

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2023-03-01
  • 最后修改日期:2024-02-27
  • 錄用日期:2023-07-28
  • 在線發布日期: 2024-03-22
  • 出版日期: 2024-03-20