1-xCex)2.4Fe14B (x=0, 0.2, 0.4, 0.6, 0.8, 0.8, 1.0)的快淬帶，研究了Ce取代量對快淬帶的相組成、磁性能和微觀結構的影響。XRD結果表明，所有快淬帶均呈現四方結構(Nd, Ce)2Fe14B相，當Ce取代量超過x=0.6時，快淬帶中出現CeFe2相并且CeFe2含量隨著Ce取代量的增加而增加。快淬帶的剩磁、剩磁比（Mr/Ms）和晶格常數隨著Ce含量的增加而減小，當Ce取代量為x=0.2時，快淬帶的磁性能為矯頑力1.31×106 A/m，最大磁能積103 kJ/m3。通過小回線和δM曲線研究了快淬帶的矯頑力機理和晶粒間交換耦合，在每個樣品中都觀察到正的δM值，證實了交換耦合相互作用的存在。Ce含量為x=0.2時δM最大值達到0.76，說明快淬帶晶粒間交換耦合效應最強，這一結果與剩磁比的變化一致。SEM觀察發現，Ce取代量的增加惡化快淬帶的柱狀晶結構。"/>

最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
NdCeFeB快淬帶相互作用與磁性能
作者:
作者單位:

1.內蒙古科技大學 理學院，內蒙古 包頭 014010;2.內蒙古科技大學 分析測試中心，內蒙古 包頭 014010

作者簡介:

通訊作者:

中圖分類號:

基金項目:

National Key Research and Development Program of China (2022YFB3505800)；NSFC(51761031、51961031); Natural Science Foundation of Inner Mongolia Autonomous Region (Grant No. 2019MS05040)


Interaction and Magnetic Properties of NdCeFeB Melt-Spun Ribbons
Author:
Affiliation:

1.School of Science, Inner Mongolia University of Science and Technology, Baotou 014010, China;2.Instrumental Analysis Center, Inner Mongolia University of Science and Technology, Baotou 014010, China

Fund Project:

National Key Research and Development Program of China (2022YFB3505800); National Natural Science Foundation of China (51761031, 51961031); Natural Science Foundation of Inner Mongolia Autonomous Region (2019MS05040)

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    采用感應熔煉制備名義成分為(Nd1-xCex)2.4Fe14B (x=0, 0.2, 0.4, 0.6, 0.8, 0.8, 1.0)的快淬帶，研究了Ce取代量對快淬帶的相組成、磁性能和微觀結構的影響。XRD結果表明，所有快淬帶均呈現四方結構(Nd, Ce)2Fe14B相，當Ce取代量超過x=0.6時，快淬帶中出現CeFe2相并且CeFe2含量隨著Ce取代量的增加而增加?？齑銕У氖４?、剩磁比（Mr/Ms）和晶格常數隨著Ce含量的增加而減小，當Ce取代量為x=0.2時，快淬帶的磁性能為矯頑力1.31×106 A/m，最大磁能積103 kJ/m3。通過小回線和δM曲線研究了快淬帶的矯頑力機理和晶粒間交換耦合，在每個樣品中都觀察到正的δM值，證實了交換耦合相互作用的存在。Ce含量為x=0.2時δM最大值達到0.76，說明快淬帶晶粒間交換耦合效應最強，這一結果與剩磁比的變化一致。SEM觀察發現，Ce取代量的增加惡化快淬帶的柱狀晶結構。

    Abstract:

    The alloy ingots with nominal compositions of (Nd1-xCex)2.4Fe14B (x=0, 0.2, 0.4, 0.6, 0.8, 1.0) were prepared by induction melting and then melt-spun to form nanocrystalline ribbons. Phase composition, magnetic properties and microstructure were investigated. XRD results show that all melt-spun ribbons exhibit the tetragonal structure (Nd,Ce)2Fe14B phase. When Ce substitution content is more than x=0.6, CeFe2 phase appears and CeFe2 content increases with the increase in Ce substitution content. Remanence, remanence ratio (Mr/Ms) and lattice constant decrease while increasing Ce substitution content. A coercivity of 1.31×106 A/m and the maximum energy product of 103 kJ/m3 for (Nd0.8Ce0.2)2.4Fe14B melt-spun ribbon are achieved. The coercivity mechanism and intergrain exchange coupling were studied. The positive δM value was observed in every sample, confirming the existence of exchange coupling interaction. The δM maximum value reaches 0.76 at the Ce substitution content x=0.2, indicating that the intergranular exchange coupling effect is the strongest, which is consistent with the varying remanence ratio. SEM observation reveals that increasing Ce substitution deteriorates the columnar crystal structure of ribbons.

    參考文獻
    相似文獻
    引證文獻
引用本文

李敏敏,左建華,侯永杰,薄宇,章明,董福海,李志,劉飛,劉艷麗,白鎖,李柱柏,李永峰.NdCeFeB快淬帶相互作用與磁性能[J].稀有金屬材料與工程,2023,52(8):2732~2736.[Li Minmin, Zuo Jianhua, Hou Yongjie, Bo Yu, Zhang Ming, Dong Fuhai, Li Zhi, Liu Fei, Liu Yanli, Bai Suo, Li Zhubai, Li Yongfeng. Interaction and Magnetic Properties of NdCeFeB Melt-Spun Ribbons[J]. Rare Metal Materials and Engineering,2023,52(8):2732~2736.]
DOI：10.12442/j. issn.1002-185X.20230081

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2023-02-19
  • 最后修改日期:2023-04-19
  • 錄用日期:2023-04-26
  • 在線發布日期: 2023-08-25
  • 出版日期: 2023-08-24