-1的范圍內，對Ti6321鈦合金進行動態壓縮試驗，研究溫度和應變速率對材料力學性能和變形行為的影響。采用光學顯微鏡（OM）、透射電子顯微鏡（TEM）和電子背散射衍射（EBSD）表征和分析了合金的微觀結構演變。結果表明，隨著溫度的降低和應變速率的增加，Ti6321鈦合金的動態屈服強度和平均流動應力均增大，而斷裂應變明顯降低。采用Johnson-Cook本構方程預測了Ti6321鈦合金在低溫高應變速率下的力學行為，擬合結果與實驗結果吻合較好。微觀結構分析表明，隨著變形溫度的降低，｛112｝和｛101｝2種孿晶的含量明顯增加，即變形機制逐漸由孿晶的輔助作用轉變?yōu)閷\晶占主導地位。"/>

最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
Ti-6Al-3Nb-2Zr-1Mo鈦合金在低溫高應變速率下的變形行為
作者:
作者單位:

1.北京理工大學 材料學院，北京 100081;2.北京理工大學 沖擊環境材料技術國家級重點實驗室，北京 100081;3.北京理工大學 爆炸科學與技術國家重點實驗室，北京 100081

作者簡介:

通訊作者:

中圖分類號:

基金項目:

爆炸科學與技術國家重點實驗室基金（YBKT17-06）


Deformation Behavior of Ti-6Al-3Nb-2Zr-1Mo Titanium Alloy at Low Temperatures and High Strain Rates
Author:
Affiliation:

1.School of Materials Science and Engineering, Beijing Institute of Technology, Beijing 100081, China;2.National Key Laboratory of Science and Technology on Materials Under Shock and Impact, Beijing Institute of Technology, Beijing 100081, China;3.State Key Laboratory of Explosion Science and Technology, Beijing Institute of Technology, Beijing 100081, China

Fund Project:

State Key Laboratory of Explosive Science and Technology Fund (YBKT17-06)

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    在變形溫度為193~298 K、應變速率為2000~3000 s-1的范圍內，對Ti6321鈦合金進行動態壓縮試驗，研究溫度和應變速率對材料力學性能和變形行為的影響。采用光學顯微鏡（OM）、透射電子顯微鏡（TEM）和電子背散射衍射（EBSD）表征和分析了合金的微觀結構演變。結果表明，隨著溫度的降低和應變速率的增加，Ti6321鈦合金的動態屈服強度和平均流動應力均增大，而斷裂應變明顯降低。采用Johnson-Cook本構方程預測了Ti6321鈦合金在低溫高應變速率下的力學行為，擬合結果與實驗結果吻合較好。微觀結構分析表明，隨著變形溫度的降低，｛112｝和｛101｝2種孿晶的含量明顯增加，即變形機制逐漸由孿晶的輔助作用轉變?yōu)閷\晶占主導地位。

    Abstract:

    Dynamic compression tests of Ti6321 titanium alloy were carried out in the temperature range from 193 K to 298 K and strain rate range from 2000 s-1 to 3000 s-1 to study the effects of temperature and strain rate on the mechanical properties and deformation behavior of the alloy. The microstructure evolution was observed and analyzed by optical microscope (OM), transmission electron microscope (TEM) and electron backscatter diffraction (EBSD). The results show that with decreasing temperature and increasing strain rate, dynamic yield strength and average flow stress of Ti6321 titanium alloy increase, while the fracture strain decreases obviously. Johnson-Cook constitutive equation is used to predict the mechanical behavior at low temperatures and high strain rates, and the fitting results are in good agreement with the experimental ones. Microstructural study shows that the content of the {112} and {101} extension twins increases significantly as the deformation temperature decreases. The deformation mechanism gradually changes from the auxiliary role of twins to the dominance of twins.

    參考文獻
    相似文獻
    引證文獻
引用本文

李嚴星,王琳,安瑞,趙平洛,閆志維,程煥武,程興旺.Ti-6Al-3Nb-2Zr-1Mo鈦合金在低溫高應變速率下的變形行為[J].稀有金屬材料與工程,2022,51(12):4369~4375.[Li Yanxing, Wang Lin, An Rui, Zhao Pingluo, Yan Zhiwei, Cheng Huanwu, Cheng Xingwang. Deformation Behavior of Ti-6Al-3Nb-2Zr-1Mo Titanium Alloy at Low Temperatures and High Strain Rates[J]. Rare Metal Materials and Engineering,2022,51(12):4369~4375.]
DOI：10.12442/j. issn.1002-185X.20220181

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2022-03-08
  • 最后修改日期:2022-05-19
  • 錄用日期:2022-06-16
  • 在線發布日期: 2023-01-11
  • 出版日期: 2022-12-30