最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
Incoloy825合金熱變形為與組織演變
作者:
作者單位:

太原科技大學 材料科學與工程學院

作者簡介:

通訊作者:

中圖分類號:

基金項目:

山西省關鍵核心技術和共性技術研發公關專項(項目號20201102017)


Microstructure evolution and hot deformation behavior of Incoloy825 alloy
Author:
Affiliation:

Taiyuan University of Science and Technology,College of Materials Science and Engineering

Fund Project:

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    通過熱壓縮實驗，研究了Incoloy825合金在變形量為60％,溫度為950~1150℃和應變速率0.001~1s-1范圍內熱變形行為?；贏rrhenius方程和Zener-Hollomon參數模型，建立該合金的本構方程模型。采用金相顯微鏡（OM）和電子背散射衍射（EBSD）技術研究了合金的組織演變規律。結果表明，隨著變形溫度的升高或應變速率的降低，DRX的百分含量增加。熱變形過程中DRX既包括晶界弓起形核機制的不連續動態再結晶（DDRX）也包括漸進式亞晶旋轉形核機制的連續動態再結晶（CDRX）。隨著變形溫度的升高或應變速率的降低DDRX增強而CDRX減弱。此外隨著溫度的升高或應變速率的降低，低角度晶界逐漸向高角度晶界轉化。同時隨機分布的Σ3孿晶界趨于均勻化，且對動態再結晶起促進作用。

    Abstract:

    The hot deformation behavior of Incoloy 825 alloy under 60% deformation,950 ~ 1150 ℃ temperature and 0.001 ~ 1s-1 strain rate was studied by hot compression test. Based on Arrhenius equation and Zener Hollomen parameter model, the constitutive equation model of the alloy was established. The microstructure evolution of the alloy was studied by means of metallographic microscope (OM) and electron backscattering diffraction (EBSD). The results show that the percentage of DRX increases with the increase of deformation temperature or the decrease of strain rate. DRX includes both discontinuous dynamic recrystallization (DDRX) and continuous dynamic recrystallization (CDRX) during hot deformation. With the increase of deformation temperature or the decrease of strain rate DDRX increases and CDRX decreases. In addition, with the increase of temperature or the decrease of strain rate, the low angle grain boundary gradually transforms to the high angle grain boundary. Simultaneous random distribution Σ3 twin boundaries tend to homogenize, It also promotes the dynamic recrystallization.

    參考文獻
    相似文獻
    引證文獻
引用本文

鄭躍武,楚志兵,李亞杰,秦鳳鳴,武佳奇,李玉貴. Incoloy825合金熱變形為與組織演變[J].稀有金屬材料與工程,2022,51(6):2063~2072.[Zheng Yuewu, Chu Zhibing, Li Yajie, Qi Fengming, Wu Jiaqi, Li Yugui. Microstructure evolution and hot deformation behavior of Incoloy825 alloy[J]. Rare Metal Materials and Engineering,2022,51(6):2063~2072.]
DOI：10.12442/j. issn.1002-185X.20210449

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2021-05-19
  • 最后修改日期:2021-08-27
  • 錄用日期:2021-09-27
  • 在線發布日期: 2022-07-06
  • 出版日期: 2022-06-29