最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
電渣重熔用低氟渣與Incoloy825合金中Al、Ti反應性的研究
作者:
作者單位:

1.西安建筑科技大學冶金工程學院;2.北京科技大學冶金新技術國家重點實驗室

作者簡介:

通訊作者:

中圖分類號:

TF141

基金項目:

國家自然科學基金資助(項目號51774225)


Reactiveness of Low Fluorine Slag for Electroslag Remelting to Al and Ti of Incoloy 825 Alloy
Author:
Affiliation:

1.School of Metallurgical Engineering,Xian University of Architecture and Technology,Xi′an;2.State Key Laboratory of Advanced Metallurgy,University of Science and Technology Beijing

Fund Project:

The National Natural Science Foundation of China (General Program, Key Program, Major Research Plan)

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    通過高溫渣-金平衡實驗，探討了電渣重熔用低氟渣CaF2-CaO-Al2O3-MgO-Li2O-(TiO2)中TiO2含量對Incoloy825合金中Al、Ti含量的影響。并利用FactSage7.3熱力學軟件分析了渣中TiO2和Al2O3的活度與渣成分的關系。研究了渣中組元對反應4[Al]+3(TiO2)=3[Ti]+2(Al2O3)的吉布斯自由能和合金中平衡Al、Ti含量的影響規律。結果表明：反應的吉布斯自由能與渣中TiO2、CaF2和MgO呈負相關，與CaO和Al2O3呈正相關；渣中TiO2含量為0～7.27%時，合金燒鈦增鋁現象逐漸減弱，TiO2含量為11.27%時，又出現燒鋁增鈦現象；同一溫度下，隨著渣中CaO和Al2O3含量增加，合金中平衡Ti含量降低，平衡Al含量升高。隨著渣中TiO2含量增加，合金中平衡Ti含量升高，平衡Al含量降低。渣中CaF2和MgO含量變化對合金中平衡Al、Ti含量影響較小。實驗結果與熱力學計算結果能夠很好的吻合。

    Abstract:

    The effect of the content of TiO2 in CaF2-CaO-Al2O3-MgO-Li2O-(TiO2) slag on the content of Al and Ti in Incoloy 825 alloy was discussed by the high temperature slag-metal equilibrium experiment. The relationship between the activity of TiO2 and Al2O3 in slag and the compositions of slag was analyzed by FactSage 7.3 thermodynamic software. The influence rule of components in slag on Gibbs free energy of reaction 4[Al]+3(TiO2) = 3[Ti]+2(Al2O3) and the content of equilibrium Al and Ti in alloy were studied. The results show that the Gibbs free energy of the reaction is negatively correlated with TiO2, CaF2 and MgO in the slag, and positively correlated with CaO and Al2O3. When the content of TiO2 in slag is 0-7.27%, the effect of burning Ti to increase Al is gradually reduced. When the content of TiO2 is 11.27%, the effect of burning Al to increase Ti is appeared. At the same temperature, with the increase of CaO and Al2O3 content in slag, the equilibrium Ti content in alloy decreases and the equilibrium Al content increases. With the increase of TiO2 content in slag, the equilibrium Ti content in alloy increases and the equilibrium Al content decreases. The change of CaF2 and MgO content in slag has little effect on the equilibrium Al and Ti content in the alloy. The experimental results are in good agreement with the thermodynamic calculation results.

    參考文獻
    相似文獻
    引證文獻
引用本文

巨建濤,安家良,史成斌,鄭頂立,棘廣恒.電渣重熔用低氟渣與Incoloy825合金中Al、Ti反應性的研究[J].稀有金屬材料與工程,2020,49(1):233~240.[Ju Jiantao, An Jialiang, Shi Chengbin, Zheng Dingli, Ji Guangheng. Reactiveness of Low Fluorine Slag for Electroslag Remelting to Al and Ti of Incoloy 825 Alloy[J]. Rare Metal Materials and Engineering,2020,49(1):233~240.]
DOI：10.12442/j. issn.1002-185X.20190539

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2019-06-26
  • 最后修改日期:2019-09-16
  • 錄用日期:2019-09-17
  • 在線發布日期: 2020-02-16
  • 出版日期: