最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
燒結溫度對W-40vol.%ZrC性能與組織的影響
作者:
作者單位:

中南大學 粉末冶金國家重點實驗室

作者簡介:

通訊作者:

中圖分類號:

TG 146.4

基金項目:

國家自然科學基金資助(項目號51474242和51404308) 和國家科技部重大專項(項目號2014GB115000)


Effect of sintering temperature on microstructure and properties of W-40vol%ZrC
Author:
Affiliation:

State Key Laboratory for Powder Metallurgy, Central South University

Fund Project:

National Natural Science Foundation of china(grant numbers 51474242 and 51404308 ) and National Magnetic Confinement Fusion Program(grant numbers 2014GB115000 )

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    采用放電等離子燒結(SPS)和常壓氫氣燒結制備了W-40vol.%ZrC的復合材料,研究了燒結溫度對其密度、力學性能和微觀組織的影響。結果表明,采用SPS燒結能在低于常壓氫氣燒結200℃下,實現W-40vol.%ZrC的高相對密度和高強度和細晶組織。采用SPS燒結在1600℃時的相對密度、硬度和抗彎強度分別達到為98.56%、HRA78.1和501MPa,W和ZrC的平均晶粒度分別為3μm和1.5μm；而采用常壓氫氣燒結在1860℃燒結時達到最優值,其相對密度、硬度和抗彎強度達到98.95%、HRA77.3和726MPa,W和ZrC的平均晶粒度分別為10μm和4.5μm。微觀組織分析顯示SPS燒結較常壓氫氣燒結制備W-40vol.%ZrC的ZrC相分布更加均勻細小,其能減少材料變形中由于ZrC團聚造成應力集中而引發的脆性斷裂。

    Abstract:

    W-40vol%ZrC composites was prepared by spark plasma sintering (SPS) and ordinary consolidation sintering respectively. The relative density, mechanical properties and microstructure were studied. The resules show that high relative density, high strength and fine grains structure can be achieved by SPS which is reduced 200℃ to the ordinary consolidation sintering. The relative density, hardness, bending strength of W-40vol%ZrC composites sintering at 1600℃ was 98.56%, HRA78.1 and 501MPa respectively. The average grain sizes of W and ZrC was 3μm and 1.5μm. O-W40ZrC had the optimun value sintering at 1860℃, the relative of density, hardness and bending strength was 98.95%, HRA77.3 and 726MPa. The average grain sizes of W and ZrC was 10μm and 4.5μm. Compared with ordinary consolidation sintering, the tungsten grain is more fine and ZrC particles is much more well-distributed prepared by spark plasma sintering, and the fine grains has a beneficical effect on fracture process.

    參考文獻
    相似文獻
    引證文獻
引用本文

李鵬飛,范景蓮,章曼,馮康杰,韓勇,田家敏.燒結溫度對W-40vol.%ZrC性能與組織的影響[J].稀有金屬材料與工程,2019,48(1):335~340.[lipengfei, fan jinglian, zhangman, fengkangjie, hanyong, tianjiamin. Effect of sintering temperature on microstructure and properties of W-40vol%ZrC[J]. Rare Metal Materials and Engineering,2019,48(1):335~340.]
DOI：10.12442/j. issn.1002-185X.20171160

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2017-12-15
  • 最后修改日期:2018-01-07
  • 錄用日期:2018-04-04
  • 在線發布日期: 2019-02-18
  • 出版日期: