25Nd75)25Dy6Al0.5B1Co1Cu0.2Febal.的燒結Nd-Fe-B磁體,并研究了不同磁粉粒徑制備的燒結Nd-Fe-B磁體磁性能和初始磁化階段最大磁導率的相應演變規律。結果表明,磁粉平均尺寸為3.0 μm時對應的磁體的內稟矯頑力最好,磁粉平均尺寸為3.5 μm 時對應的磁體的剩磁最高。從磁體的微觀結構觀察和性能測試發現,磁粉粒徑為3.0μm時,燒結磁體主相更加規則、均勻,提高了磁體的矯頑力。隨著平均磁粉尺寸進一步減小,磁粉粒徑2.5μm時,富Nd相以氧化物形式發生了團聚,且分布不均勻,磁體晶界出現孔洞,去磁耦合效率下降,導致磁體矯頑力降低；磁體氧含量隨著磁粉平均尺寸的減小而增大,磁體內雜質相增多,剩磁下降；增多的雜質相使得磁化初始階段的最大磁導率降低。"/>

最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
磁粉粒徑對燒結Nd-Fe-B磁性能和初始磁導率的影響
作者:
作者單位:

江西理工大學 江西 贛州341000

作者簡介:

通訊作者:

中圖分類號:

TM273

基金項目:

國家高技術研究發展計劃(863計劃),(項目編號：2010AA03A401)


Effect of Particle Size on the Magnetic Properties and Initial Susceptibility of Sintered Nd–Fe–B Magnets
Author:
Affiliation:

Jiangxi University of Science and Technology,Ganzhou,China,341000

Fund Project:

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    本文采用粉末冶金方法制備了名義成分為(Pr25Nd75)25Dy6Al0.5B1Co1Cu0.2Febal.的燒結Nd-Fe-B磁體,并研究了不同磁粉粒徑制備的燒結Nd-Fe-B磁體磁性能和初始磁化階段最大磁導率的相應演變規律。結果表明,磁粉平均尺寸為3.0 μm時對應的磁體的內稟矯頑力最好,磁粉平均尺寸為3.5 μm 時對應的磁體的剩磁最高。從磁體的微觀結構觀察和性能測試發現,磁粉粒徑為3.0μm時,燒結磁體主相更加規則、均勻,提高了磁體的矯頑力。隨著平均磁粉尺寸進一步減小,磁粉粒徑2.5μm時,富Nd相以氧化物形式發生了團聚,且分布不均勻,磁體晶界出現孔洞,去磁耦合效率下降,導致磁體矯頑力降低；磁體氧含量隨著磁粉平均尺寸的減小而增大,磁體內雜質相增多,剩磁下降；增多的雜質相使得磁化初始階段的最大磁導率降低。

    Abstract:

    Particle refinement is the effective way to improve the coercive force without increasing the HRE content in Sintered Nd-Fe-B magnets. The magnetic properties and initial magnetization permeability has been investigated in order to correlate the particle refinement by traditional powder metallurgy method with nominal composition of (Pr25Nd75)25Dy6Al0.5B1Co1Cu0.2Febal sintered Nd-Fe-B magnet. The particles with average size of 3.0 μm achieved the best Hcj, and the particles with average size of 3.5 μm obtained the best Br respectively. Refined particle size which made the morphology regular and uniform. But with further decreased the average particle size, Nd rich phase was in the form of oxide, and unevened distribution in the grain boundary, and the demagnetization coupling efficiency droped, results in the decrease of Hcj. The oxidation content increased with the average size becoming samller, the Br decreased with the impurity content increased. On the other hand,the initial permeability dramatically fallen with the impurity content.

    參考文獻
    相似文獻
    引證文獻
引用本文

劉路軍,劉政.磁粉粒徑對燒結Nd-Fe-B磁性能和初始磁導率的影響[J].稀有金屬材料與工程,2019,48(2):668~672.[Liu Lujun, Liu Zheng. Effect of Particle Size on the Magnetic Properties and Initial Susceptibility of Sintered Nd–Fe–B Magnets[J]. Rare Metal Materials and Engineering,2019,48(2):668~672.]
DOI：10.12442/j. issn.1002-185X.20170456

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2017-05-31
  • 最后修改日期:2017-08-13
  • 錄用日期:2017-09-11
  • 在線發布日期: 2019-03-15
  • 出版日期: