2時,所得粉體粒度最小,純度最高；In3+濃度對粉體粒度的影響最小,但對純度影響最大；在此工藝參數和In3+濃度為30g/L,電流密度為130 A/cm2的條件下電解1h,可得到粒度小于100μm的銦微粉,其中粒度小于30μm的占75%。"/>

最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
電解工藝參數對銦微粉純度和粒度的影響(I)
DOI:
作者:
作者單位:

青海大學機械工程學院,青海大學機械工程學院,青海大學機械工程學院,東北大學冶金學院

作者簡介:

通訊作者:

中圖分類號:

基金項目:

青海省科技廳科技促進計劃項目(項目號2014-ZJ-781)


Effect of Electrolytic Process Parameters on the Purity andParticle Size of Indium Powder (I)
Author:
Affiliation:

School of Mechanical Engineering,Qinghai University,School of Mechanical Engineering,Qinghai University,School of Mechanical Engineering,Qinghai University,School of Metallurgy,Northeastern University

Fund Project:

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    研究了電解工藝制備銦微粉時,銦離子濃度、電流密度和連續電解時間對粉體純度和粒度的影響。結果表明：當電工藝參數為NaCl濃度80g/L,極距5cm,硫脲濃度0.3g/L,明膠濃度0.5g/L,pH=2.5,添加劑聚乙烯吡咯烷酮用量為0.2g/L時,連續電解時間越長,所得粉體粒度越大；電流密度為130A/m2時,所得粉體粒度最小,純度最高；In3+濃度對粉體粒度的影響最小,但對純度影響最大；在此工藝參數和In3+濃度為30g/L,電流密度為130 A/cm2的條件下電解1h,可得到粒度小于100μm的銦微粉,其中粒度小于30μm的占75%。

    Abstract:

    The effect of indium ion concentration, current density and continuous electrolysis time on the purity and size of the powder by electrolysis process was studied. The results show that：Continuous electrolysis time is longer, the larger sizes of the powder were obtained when the electric parameters are: NaCl concentration is 80g/L, polar distance is 5 cm, thiourea concentration is 0.3 g/L, gelatin concentration is 0.5 g/l, pH = 2.5, Polyvinyl ketone(PVP) is 0.2 g/L. When the current density is 130 A/m2, the particle size of the powder is the smallest, and the purity is the highest. The effect of In3+ concentration on the particle size is the least, but the influence on the purity is the most. Under the conditions of process parameters above and In3+ concentration of 30 g/L, the current density of 130 A/cm2, electrolytic for 1h, the particle size of less than 100 μm indium powder were obtained, which the particle size of less than 30 μm accounted for 75%.

    參考文獻
    相似文獻
    引證文獻
引用本文

王曉民,王志新,喇學偉,張廷安.電解工藝參數對銦微粉純度和粒度的影響(I)[J].稀有金屬材料與工程,2017,46(10):3151~3155.[Xiao-min Wang, Zhi-xin Wang, Xue-wei La, Ting-an Zhang. Effect of Electrolytic Process Parameters on the Purity andParticle Size of Indium Powder (I)[J]. Rare Metal Materials and Engineering,2017,46(10):3151~3155.]
DOI：[doi]

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2016-08-05
  • 最后修改日期:2016-09-26
  • 錄用日期:2016-12-07
  • 在線發布日期: 2017-12-01
  • 出版日期: