2Sn相組成,Mg2Sn相在界面處產生。在制備溫度為570 ℃時彎曲強度最高,可達215 MPa。當燒結溫度為590 ℃時鎂合金的耐腐蝕性能最好,其電化學的電極電位和腐蝕電流分別為-1.5218 V和1.9632×10-5 A/cm2,這主要是由于Mg2Sn在顆粒接合邊界的存在,對α-Mg起到保護作用。"/>

最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
Mg-8Sn系鎂合金SPS制備及其組織性能研究
DOI:
作者:
作者單位:

先進鎂基材料山西省重點實驗室,先進鎂基材料山西省重點實驗室,先進鎂基材料山西省重點實驗室,先進鎂基材料山西省重點實驗室

作者簡介:

通訊作者:

中圖分類號:

基金項目:

國家自然科學基金資助(項目號51375328)


The research of the microstructure and properties ofMg-8Sn alloy prepared by SPS
Author:
Affiliation:

Fund Project:

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    基于Mg-8Sn系鎂合金具有較好的強度、耐腐蝕性和塑性加工性,本文采用放電等離子燒結方法(Spark plasma sintering：SPS)在530～590 ℃制備了Mg-8Sn-1Al-1Zn鎂合金,對鎂合金的微觀組織、物相、力學性能和耐腐蝕性能進行了研究。結果表明：鎂合金的顯微組織由α-Mg和Mg2Sn相組成,Mg2Sn相在界面處產生。在制備溫度為570 ℃時彎曲強度最高,可達215 MPa。當燒結溫度為590 ℃時鎂合金的耐腐蝕性能最好,其電化學的電極電位和腐蝕電流分別為-1.5218 V和1.9632×10-5 A/cm2,這主要是由于Mg2Sn在顆粒接合邊界的存在,對α-Mg起到保護作用。

    Abstract:

    Based on the better strength, corrosion resistance and plastic processing of Mg-8Sn alloy, Mg-8Sn alloy was prepared successfully in 530～590 ℃ by spark plasma sintering (SPS) in this paper. The microstructures, phases, mechanical properties and corrosion resistance were investigated. The research results showed that the microstructure consisted of α-Mg and Mg2Sn phases, while Mg2Sn was generated at the interface of Mg and Sn. The highest bending strengh of Mg-8Sn-1Zn-1Al was 215 MPa which was obtained at 570 ℃. The best corrosion resistance of Mg-8Sn-1Zn-1Al was obtained at 590 ℃, of which the corrosion potential and the corrosion current were respectively -1.5218 V, 1.9632×10-5 A/cm2. That was because Mg2Sn was existed at particles bonding interface, which had protective effects on α-Mg.

    參考文獻
    相似文獻
    引證文獻
引用本文

劉芳芳,王文先,陳洪勝,張媛琦. Mg-8Sn系鎂合金SPS制備及其組織性能研究[J].稀有金屬材料與工程,2018,47(7):2159~2165.[liufangfang, wangwenxian, chenhongsheng, zhangyuanqi. The research of the microstructure and properties ofMg-8Sn alloy prepared by SPS[J]. Rare Metal Materials and Engineering,2018,47(7):2159~2165.]
DOI：[doi]

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2016-07-12
  • 最后修改日期:2016-09-14
  • 錄用日期:2016-10-18
  • 在線發布日期: 2018-10-10
  • 出版日期: