最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
真空感應重熔GH3625合金純凈化研究
DOI:
作者:
作者單位:

蘭州理工大學省部共建有色金屬先進加工與再利用國家重點實驗室,蘭州理工大學省部共建有色金屬先進加工與再利用國家重點實驗室

作者簡介:

通訊作者:

中圖分類號:

TF 133+.2

基金項目:

甘肅省重大科技專項資助項目(145RTSA004)


Investigation of Purification in Alloy GH3625 throughVacuum Induction Remelting
Author:
Affiliation:

State Key Laboratory of Adwanced Processing and Recyling of Nonferrous Metals,Lanzhou University of Technology,State Key Laboratory of Adwanced Processing and Recyling of Nonferrous Metals,Lanzhou University of Technology

Fund Project:

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    為進一步降低GH3625母合金中的氧、氮、硫含量,分別進行了高真空不加鈣和高真空向合金熔體加鈣兩種工藝條件下的真空感應重熔實驗,研究了高真空感應重熔精煉對合金成分和去除雜質元素氧、氮、硫的作用。結果表明：高真空感應重熔元素?fù)]發燒損和富化均控制在標準成分范圍；單純高真空感應重熔時，合金中的氧通過C-O反應脫除,可脫氧至10ppm,氮分壓降低使氮含量脫至70ppm,但在去硫方面無明顯作用；高真空加0.5%鈣作凈化劑重熔時，Ca-O反應以及Ca與Al2O3坩堝內壁反應,可實現深度脫氧,通過Ca-S反應使合金中硫含量顯著降低,然而氮含量降低程度有限,其含量遠高于氮在GH3625合金中的溶解度。采用Al2O3坩堝,選擇高真空熔煉工藝及適量鈣的加入,可使氧、氮、硫含量分別降低到6、60、9ppm。

    Abstract:

    For further reduction of oxygen, nitrogen and sulphur contents in master alloy GH3625, two vacuum induction remelting experiments (high vacuum without calcium and high vacuum with addition calcium) were carried out. Alloy composition and purity were investigated. The results show that: under high vacuum induction remelting burning loss and enrichment of alloying elements are all in the range of standard composition; deoxidation is excellent under high vacuum induction remelting, O content is reduced from 17ppm to 10ppm by C-O reaction; but removal of nitrogen and sulphur is not obvious; High vacuum induction remelting with addition Ca using Al2O3 Ca-O and Ca-Al2O3 (the inner wall of crucible) reaction is helpful to deep deoxidation, Ca-S reaction makes S content is greatly reduced, reducing nitrogen content is limited, it is far higher than N solubility in alloy GH3625. In Al2O3 crucible, adopting high vacuum melting technology and proper calcium addition amounts, oxygen, nitrogen and sulphur content could be reduced to 6ppm,60ppm and 9ppm respectively.

    參考文獻
    相似文獻
    引證文獻
引用本文

丁雨田,王 偉.真空感應重熔GH3625合金純凈化研究[J].稀有金屬材料與工程,2018,47(2):687~691.[Ding Yutian, Wang Wei. Investigation of Purification in Alloy GH3625 throughVacuum Induction Remelting[J]. Rare Metal Materials and Engineering,2018,47(2):687~691.]
DOI：[doi]

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2015-12-24
  • 最后修改日期:2016-03-17
  • 錄用日期:2016-03-29
  • 在線發布日期: 2018-03-15
  • 出版日期: