最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
鎢螺旋線表面鍍金薄膜熱可靠性研究
DOI:
作者:
作者單位:

北京工業大學,北京工業大學,北京工業大學,北京工業大學,北京工業大學

作者簡介:

通訊作者:

中圖分類號:

TB34

基金項目:

國防科工局


Study on thermal reliability of Gold Filmon the surface of Tungsten Helix
Author:
Affiliation:

Beijing University of Technology,Beijing University of Technology,Beijing University of Technology,Beijing University of Technology,Beijing University of Technology

Fund Project:

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    鎢螺旋線是行波管的關鍵部件,隨著行波管功率量級和工作頻率的不斷提高,其高頻損耗和散熱問題更加突出。為了解決這些問題,前期研究了鎢螺旋線表面鍍覆金膜的方法。由于螺旋線的工作溫度較高,鍍金薄膜的熱可靠性如何？因此本文采用納米劃痕技術測試鍍金薄膜和基體之間結合力大小,對預鍍銅5s,10s,15s和20s,鍍金均為1.5h后的試樣高溫(500℃,100h)處理前后的膜-基結合力進行了對比分析。結果表明：預鍍銅5s,15s和20s的試樣經高溫處理后的膜-基結合力大小與常溫下相比沒有明顯降低；預鍍銅10s時的試樣經高溫處理后的膜-基結合力與常溫下相比有所增大。鎢螺旋線表面鍍金薄膜熱可靠性好。

    Abstract:

    Tungsten helix is a component of transfer wave tube (TWT), its high frequency loss and heat dissipation become serious with power level and working frequency of TWT increasing. To solve the problems, gold thin films were deposited on the surface of helix in our previous. How is the thermal reliability of gold thin films when helix operates at higher temperature? In this paper, the binding force between gold film and substrate was tested by using nanoscratch. The film binding forces of samples pre-plated copper respectively for 5s,10s,15s,20s and then gold-plated for 1.5h before and after heat treatment were analyzed.The results indicate that the films adhesion of samples after heat treatment show no obvious decrease compared with those of as-deposited samples. Especially, the binding force of the sample pre-plated copper for 10s after heat increases . The thermal reliability of gold films is good.

    參考文獻
    相似文獻
    引證文獻
引用本文

范愛玲,李偉田,薛迎坤,常隨杰,馬捷.鎢螺旋線表面鍍金薄膜熱可靠性研究[J].稀有金屬材料與工程,2016,45(7):1788~1792.[Fan Ailing, Li Weitian, Xue Yingkun, Chang Suijie, Ma Jie. Study on thermal reliability of Gold Filmon the surface of Tungsten Helix[J]. Rare Metal Materials and Engineering,2016,45(7):1788~1792.]
DOI：[doi]

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2015-09-29
  • 最后修改日期:2015-12-28
  • 錄用日期:2016-01-14
  • 在線發布日期: 2016-10-09
  • 出版日期: