最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
VC/Cr3C2及配碳量對WC-0.5Co超細硬質合金組織與性能的影響
DOI:
作者:
作者單位:

作者簡介:

通訊作者:

中圖分類號:

基金項目:

硬質合金國家重點實驗室開放課題 (201103002)；國家杰出青年科學基金 (50925416)


Influence of VC/Cr3C2 and Mixed Carbon Content on Microstructure and Properties of Ultrafine WC-0.5Co Cemented Carbide
Author:
Affiliation:

Fund Project:

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    以超細WC粉末和超細WC-6Co復合粉末為原料，添加VC/Cr3C2作為晶粒長大抑制劑，同時進行配碳，采用高能球磨和氣壓強化燒結制備晶粒度小于0.5 μm的WC-0.5Co超細硬質合金，研究了不同VC/Cr3C2添加量及配碳量對其組織與性能的影響。結果表明：VC/Cr3C2有效抑制了燒結過程中WC晶粒的長大，顯著提高了WC-0.5Co超細硬質合金的硬度。當VC/Cr3C2添加量為0.73%（質量分?jǐn)?shù)，下同）時，合金的硬度（HV0.05）最高，達到32 658 MPa；同時一定的配碳量有利于控制合金中的脫碳，提高合金性能，當配碳量為0.2%時，WC-0.5Co-0.73VC/Cr3C2合金的綜合力學性能最好，斷裂韌性為6.935 MPa·m1/2，維氏硬度（HV0.05）為32 216 MPa

    Abstract:

    The ultrafine WC-0.5Co cemented carbide with a grain size smaller than 0.5 μm was prepared by high energy ball milling and HIP-sintering process. The raw materials were ultrafine WC and WC-0.5Co powder and the additives of grain growth inhibitor were VC/Cr3C2 and carbon. Microstructure and properties of the ultrafine WC-0.5Co cemented carbide with different VC/Cr3C2 and carbon contents were studied. The results show that there is a significant effect of VC/Cr3C2 on controlling WC particle size and hardness of ultrafine WC-0.5Co cemented carbide. Ultrafine WC-0.5Co cemented carbide has best Vickers hardness HV0.05 of 32 658 MPa with the VC/Cr3C2 content of 0.73% (mass fraction, similarly hereinafter). A certain amount of mixed carbon content is good for decarburization and properties of the ultrafine binderless cemented carbide. Ultrafine WC-0.5Co-073VC/Cr3C2 cemented carbide has best comprehensive mechanical properties with transverse rupture strength of 6.935 MPa·m1/2 and Vickers hardness HV0.05 of 32 216 MPa when the mixed content of carbon is 0.2%

    參考文獻
    相似文獻
    引證文獻
引用本文

鄭虎春,范景蓮,楊文華,張忠健,劉 濤. VC/Cr3C2及配碳量對WC-0.5Co超細硬質合金組織與性能的影響[J].稀有金屬材料與工程,2015,44(4):912~917.[Zheng Huchun, Fan Jinglian, Yang Wenhua, Zhang Zhongjian, Liu Tao. Influence of VC/Cr3C2 and Mixed Carbon Content on Microstructure and Properties of Ultrafine WC-0.5Co Cemented Carbide[J]. Rare Metal Materials and Engineering,2015,44(4):912~917.]
DOI：[doi]

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2014-04-13
  • 最后修改日期:
  • 錄用日期:
  • 在線發布日期: 2015-06-08
  • 出版日期: