最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
Al-Cu-Li合金均勻化處理參數優化和微觀組織演化
DOI:
作者:
作者單位:

北京有色金屬研究總院,北京有色金屬研究總院,北京有色金屬研究總院,北京有色金屬研究總院,北京有色金屬研究總院,北京有色金屬研究總院

作者簡介:

通訊作者:

中圖分類號:

基金項目:


Homogenization treatment parameter optimization and microstructural evolution of Al-Cu-Li alloy
Author:
Affiliation:

General Research Institute for Nonferrous Metals,General Research Institute for Nonferrous Metals,General Research Institute for Nonferrous Metals,General Research Institute for Nonferrous Metals,General Research Institute for Nonferrous Metals,General Research Institute for Nonferrous Metals

Fund Project:

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    摘 要：對Al-Cu-Li鑄態合金進行單級和雙級均勻化處理，通過光學顯微鏡（OM）、掃描電鏡（SEM）、能譜分析（EDS）、X衍射（XRD）和差熱分析（DSC）研究合金元素分布和微觀組織演化，結果表明：Al-Cu-Li合金鑄態組織存在嚴重枝晶偏析，由晶內到晶界Cu元素分布十分不均勻，Mg、Zn、Mn和Ag變化不明顯。晶界處存在大量的非平衡共晶相，主要包括Al2Cu、含有少量Mg元素的Al2Cu相，以及Al2CuMg相。經雙級均勻化（495℃×24h 515℃×24h）處理后，大部分非平衡共晶相和部分第二相（Al2CuMg和Al2CuLi）溶解到合金基體，但仍有部分富-Fe和富-Mn相殘留在晶界不能回溶。Al2CuMg相的熔點低于Al2Cu相，兩者分別在495℃和515℃先后溶解。通過均勻化動力學分析，確定Al-Cu-Li鋁鋰合金最佳的均勻化制度為495℃×24h 515℃×24h，該雙級均勻化制度與動力學分析結果一致。

    Abstract:

    Abstract: The microstructure evolution and composition distribution of the industrially cast Al-Cu-Li alloy during single-step and tow-step homogenization were investigated in detail by means of optical microscopy(OM), scanning electron microscopy (SEM), energy dispersive spectrometry (EDS), X-ray diffraction (XRD) and differential scanning calorimetry (DSC).The results show that severe dendrite segregation exists in the Al-Cu-Li as-cast alloy. Cu distribute unevenly from the grain boundary to inside. But the change of Mg, Zn, Mn and Ag are not obvious. In the grain boundary, there are distributed a large number of coarse nonequilibrium eutectic phases Al2Cu, Al2Cu dissolved a small amount of Mg and Al2CuMg phase. After?optimized two-step?homogenization treatment, most of the nonequilibrium?eutectic?phase and second phase(Al2CuMg and Al2CuLi)?dissolved?into ɑ(Al) matrix. A small amount of Fe-rich and Mn-rich phase are still distributed at the grain boundaries. Al2CuMg phase melting point lower than?the melting point of Al2Cu phase. Al2CuMg and Al2Cu phase gradually dissolved into matrix at 495℃ and 515℃, respectively. The suitable homogenization treatment for the Al-Cu-Li alloy is 495℃×24h 515℃×24h. The results of homogenization can be described by homogenization kinetic analysis, which agrees well with experimental observation.

    參考文獻
    相似文獻
    引證文獻
引用本文

楊勝利,沈健,閆曉東,李錫武,張飛,孫寶慶. Al-Cu-Li合金均勻化處理參數優化和微觀組織演化[J].稀有金屬材料與工程,2017,46(1):28~34.[yang sheng li, shen jian, yan xiao dong, lixiwu, zhangfei, sun bao qing. Homogenization treatment parameter optimization and microstructural evolution of Al-Cu-Li alloy[J]. Rare Metal Materials and Engineering,2017,46(1):28~34.]
DOI：[doi]

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2014-09-30
  • 最后修改日期:2014-11-03
  • 錄用日期:2015-01-13
  • 在線發布日期: 2017-03-16
  • 出版日期: