最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
TC4合金表面TiNi/Ti2Ni改性層不同載荷滑動干摩擦性能研究
DOI:
作者:
作者單位:

作者簡介:

通訊作者:

中圖分類號:

基金項目:

國家自然科學基金 (51071106, 50671071)；山西省自然科技基礎研究基金（2008012008-3）；國家“863”計劃項目（2007AA03Z521）


Study on Sliding Dry Friction Properties of TiNi/Ti2Ni Modified Layer on TC4 Alloy under Different Loads
Author:
Affiliation:

Fund Project:

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    利用等離子表面合金化技術在Ti6Al4V合金表面制備了TiNi/Ti2Ni合金層，考察了合金層的表面形貌、成分分布、截面組織形貌、相結構。采用球盤磨損試驗機分析了TiNi/Ti2Ni合金層在不同載荷下的滑動干摩擦學性能，并與基體進行對比。結果表明，基體和TiNi/Ti2Ni合金層磨損機制主要表現為磨粒磨損。在同一磨損條件下，TiNi/Ti2Ni合金層的摩擦系數略低于基體，耐磨性優于基體。TiNi/Ti2Ni合金層在不同載荷的摩擦系數接近，在0.29~0.32之間波動。隨著載荷的增加，磨損率增加。

    Abstract:

    TiNi/Ti2Ni alloyed layer was prepared on surface of Ti6Al4V alloy by plasma surface alloying process. Surface morphology, composition distribution, cross-section morphology and phase structure of Ni modified layer were analyzed. Sliding dry friction performance of TiNi/Ti2Ni alloyed layer was observed and analyzed under different loads by Pin-on-disc test, and compared with the TC4 substrate. The results indicate that the wear mechanism of both TiNi/Ti2Ni alloyed layer and the TC4 substrate shows abrasion wear. Under the same wear condition, the friction coefficient of TiNi/Ti2Ni alloyed layer is slightly lower than that of the TC4 substrate, the wear resistance of TiNi/Ti2Ni alloyed layer is better than that of TC4 substrate. Friction coefficients under different loads fluctuate between 0.29~0.33 and wear rate increases with increasing of load.

    參考文獻
    相似文獻
    引證文獻
引用本文

王振霞,賀志勇,王英芹,劉小萍,唐 賓. TC4合金表面TiNi/Ti2Ni改性層不同載荷滑動干摩擦性能研究[J].稀有金屬材料與工程,2012,41(7):1186~1190.[Wang Zhenxia, He Zhiyong, Wang Yingqin, Liu Xiaoping, Tang Bin. Study on Sliding Dry Friction Properties of TiNi/Ti2Ni Modified Layer on TC4 Alloy under Different Loads[J]. Rare Metal Materials and Engineering,2012,41(7):1186~1190.]
DOI：[doi]

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2011-07-25
  • 最后修改日期:
  • 錄用日期:
  • 在線發布日期:
  • 出版日期: