最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
高溫900 ℃回火在燒結NdFeB制備中的作用
DOI:
作者:
作者單位:

作者簡介:

通訊作者:

中圖分類號:

基金項目:

國家自然科學基金（20806093），山東省自然科學基金（ZR2011EMQ001），青島市計劃（11-2-4-4-(10)-jch），中央高?；究蒲袠I(yè)務費


Effect of High Temperature 900 oC Tempering on Magnetic Properties of NdFeB
Author:
Affiliation:

Fund Project:

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    高溫回火處理對燒結釹鐵硼磁體性能影響研究表明：經不同高溫T1回火處理后再低溫T2=600 ℃回火處理，磁體剩磁Br和矯頑力iHc隨T1溫度升高而增大，在900 ℃時有最佳值，進一步升高T1磁體的Br和iHc下降。在相同T2回火條件?下，經歷高溫回火的磁體比未經高溫回火的iHc明顯更高，但Br較低。而且無論磁體是否經過高溫回火，T2從450升到600 ℃時，Br、最大磁能積(BH)m緩慢增大，iHc顯著提高，T2在600 ℃時磁性能達到最佳。磁體顯微組織分析表明：經高溫900 ℃回火可使燒結態的磁體主相內部大量分散的不均勻非晶相消失，而且使晶粒邊界變得清晰、均勻，能較好的抑制硬磁性相間交換耦合作用，磁體矯頑力大幅提高。

    Abstract:

    Effect of high temperature (T1) tempering on sintered NdFeB magnets was investigated. With increased T1 tempering of magnets, both Br and iHc are improved after low temperature T2 tempering at 600 oC, and optimum T1 is 900 oC. As T1 increases further, Br and iHc begin to decrease. Magnets experiencing T1 tempering own higher iHc but lower Br compared with magnets of free T1 tempering. Whether the magnets experience T1 tempering or not, both Br and (BH)m increase gradually while iHc increases greatly when low temperature T2 tempering increases. The optimum T2 is 600 oC. Microstructure analysis shows that there is a large amount of non-uniform phases in the main phase of sintered magnets, and they act as nuclear centers of reversal magnetism and result in iHc decreasing. After T1 tempering, the non-uniform phases disappear in the main phase and the grain boundary becomes clear and smooth, inhabiting the interaction between Nd2Fe14B grains. So the value of iHc for the tempered magnets is improved a lot.

    參考文獻
    相似文獻
    引證文獻
引用本文

于濂清,張亞萍,鐘曉亮.高溫900 ℃回火在燒結NdFeB制備中的作用[J].稀有金屬材料與工程,2012,41(1):157~160.[Yu Lianqing, Zhang Yaping, Zhong Xiaoliang. Effect of High Temperature 900 oC Tempering on Magnetic Properties of NdFeB[J]. Rare Metal Materials and Engineering,2012,41(1):157~160.]
DOI：[doi]

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2011-01-27
  • 最后修改日期:
  • 錄用日期:
  • 在線發布日期:
  • 出版日期: