最新色国产精品精品视频,中文字幕日韩一区二区不卡,亚洲有码转帖,夜夜躁日日躁狠狠久久av,中国凸偷窥xxxx自由视频

+高級檢索
VPS-EBW法制備W／Cu功能梯度材料及熱負荷實驗研究
DOI:
作者:
作者單位:

作者簡介:

通訊作者:

中圖分類號:

TG113.2 TB34

基金項目:

國家自然科學基金項目（10475080）資助


Fabrication of W/Cu Functionally Graded Materials Used for Nuclear Fusion Devices by VPS-EBW Method and Research of Electron Beam Radiation
Author:
Affiliation:

Fund Project:

  • 摘要
    • |
  • 圖/表
    • |
  • 訪問統計
    • |
  • 參考文獻
    • |
  • 相似文獻
    • |
  • 引證文獻
    • |
  • 資源附件
    • |
  • 文章評論
    摘要:

    采用真空等離子體噴涂-電子束焊接法制備出核聚變面對等離子體W／Cu功能梯度材料，梯度材料中成分分布均勻、密度較高。電子束輻照熱負荷實驗發現：8MW／m^2的熱負荷條件下，樣品可以承受20s的輻照：在2．5Mw／m^2，4．5MW／m^2，6MW／m^2的熱負荷條件下，樣品可分別承受26s，22s，20s的輻照而沒有出現明顯的損傷現象。樣品疲勞實驗也表現出很好的性能：8MW／m^2，10s輻照，可以承受70周熱疲勞：6MW／m^2，20s輻照，在第90周裂紋開始形成；在2．5MW／m^2，輻照時間為30s和4．5MW／m^2，輻照時間為25s條件下，樣品經過100周熱疲勞實驗均沒有出現明顯的損傷現象。對已出現裂紋的斷面作X射線能量色散能譜（EDS）分析發現，由于焊料本身或者焊接時引入的雜質和虛焊，導致材料承受較高熱負荷實驗時的熱應力迅速增大到破裂極限，使表面溫度快速升高，而導致材料連接失效。

    Abstract:

    This paper introduces the fabrication method of W/Cu-FGM by Vacuum Plasma Spraying & Electron Beam Welding.Specimen could endure 20 s pluses under heat fluxes of 8 MW/m2.No damages appeared in the tested specimens which endured 26 s,22 s,20 s pluses under 2.5 MW/m2,4.5 MW/m2,6 MW/m2,respectively.Good performances were presented in the fatigue tests of the specimens.The specimens could endure 70 cycles fatigue under 6 MW/m2 and 20 s pluses;No damages appeared after the specimens were subject to 100 cyles fatigue test under 2.5 MW/m2,30 s and 4.5 MW/m2,25 s.Crack began to come into being during 90 cycles fatigue at the heat fluxes of 6 MW/m2,enduring 20 s.The specimen was analyzed by EDS.Impurities and pores were observed.

    參考文獻
    相似文獻
    引證文獻
引用本文

種法力 陳俊凌 李建剛. VPS-EBW法制備W／Cu功能梯度材料及熱負荷實驗研究[J].稀有金屬材料與工程,2006,35(9):1509~1512.[Chong Fali, Chen Junling, Li Jiangang. Fabrication of W/Cu Functionally Graded Materials Used for Nuclear Fusion Devices by VPS-EBW Method and Research of Electron Beam Radiation[J]. Rare Metal Materials and Engineering,2006,35(9):1509~1512.]
DOI：[doi]

復制
文章指標
  • 點擊次數:
  • 下載次數:
  • HTML閱讀次數:
  • 引用次數:
歷史
  • 收稿日期:2005-09-28
  • 最后修改日期:2005-09-28
  • 錄用日期:
  • 在線發布日期:
  • 出版日期: